Heavy Smoke in Exhaust
Moderator: Fatmobile
Heavy Smoke in Exhaust
Recently purchased a 1982 Westy pop top with a 1.6L diesel engine. I tightened down some bolts, but it still has minor oil leakage. Pulled the injectors, but could not separate them into halves without a sturdy vise. Cleaned most of the carbon off the outsides, though. We drove it 450 miles to its new home. There was thick black smoke (sometimes white) from the exhaust the whole trip. Actually pulled over by a trooper for smoke. At trip's end, the back hatch was covered with oil and soot. Got about 25 mpg the first day and closer to 20 the 2nd day. Used 2 quarts oil. A swab run into the muffler brings out soot, no oil. Van accelerates from 0 to 50 in about 35 seconds. Any suggestions on how to proceed?
You do not have the required permissions to view the files attached to this post.
Re: Heavy Smoke in Exhaust
a compression test would be a good idea. Also Jack the forum owner sells rebuilt injectors so if you have one sticking a set of rebuilt injectors would be a very good investment. Leaking injectors can cause some nasty overfueling problems. Also someone may have turned the pump up for more power but if that were the case it probably would not smoke like that dueing normal cruising, only when accelerating hard.
Bob
'06 Jetta TDI
'82 Rabbit 1.6NA
Honda, 99 GMC Suburban, '41 Chevy Coupe
'06 Jetta TDI
'82 Rabbit 1.6NA
Honda, 99 GMC Suburban, '41 Chevy Coupe
Re: Heavy Smoke in Exhaust
Thank you, bscutt.
-
- Global Moderator
- Posts: 7574
- Joined: Wed Oct 30, 2002 10:28 pm
- Location: north central Iowa
Re: Heavy Smoke in Exhaust
How's your air filter?
'91 Golf gasser converted to a 12mm pump, M-TDI.
'84 1.6TD Rabbit with a VNT-15 turbo, still setup to run on vegetable oil.
'84 GTI with 1.7TD pistons and intercooled.
2003 TDI wagon
2000 TDI Jetta.
'84 1.6TD Rabbit with a VNT-15 turbo, still setup to run on vegetable oil.
'84 GTI with 1.7TD pistons and intercooled.
2003 TDI wagon
2000 TDI Jetta.
Re: Heavy Smoke in Exhaust
Thanks all. Quick update. Air filter was fine. Installing rebuilt fuel injectors helped noticeably, but still plenty of smoke. I ordered timing and compression test tools. Using VinceWaldon and Bentley as references I adjusted the timing belt. With cam shaft at TDC the fly wheel notch was almost outside the viewing window. Injection pump position was fine. Smoke improved dramatically. I still get some at start and when revving.
Compression psi values were a little low (380, 410, 420, 390), but not that far from each other.
Could a molybdenum sulfide oil additive help improve the compression?
Compression psi values were a little low (380, 410, 420, 390), but not that far from each other.
Could a molybdenum sulfide oil additive help improve the compression?
-
- Global Moderator
- Posts: 7574
- Joined: Wed Oct 30, 2002 10:28 pm
- Location: north central Iowa
Re: Heavy Smoke in Exhaust
If valve timing helped so much,.. have you checked your valve clearances lately?
'91 Golf gasser converted to a 12mm pump, M-TDI.
'84 1.6TD Rabbit with a VNT-15 turbo, still setup to run on vegetable oil.
'84 GTI with 1.7TD pistons and intercooled.
2003 TDI wagon
2000 TDI Jetta.
'84 1.6TD Rabbit with a VNT-15 turbo, still setup to run on vegetable oil.
'84 GTI with 1.7TD pistons and intercooled.
2003 TDI wagon
2000 TDI Jetta.