Battery Light not turning on when ING. is engaged

Technical questions and answers concerning all models of VW diesel vehicles.

Moderator: Fatmobile

Post Reply
surfing07
Glow Plug
Posts: 12
Joined: Sat Aug 04, 2007 1:38 pm

Battery Light not turning on when ING. is engaged

Post by surfing07 »

Hello there VWers, my issue is with the battery light not turning on when the Ignition is engaged in the start and run positions. I have 12.4v @ batt. fully bench tested bosch alt. in working condition. My alt. does not seem to be charging the battery, with vehicle running I am only getting 12.2 to 12.4v when lights turned on the voltage drops to below 12v. Any ideas would be great.
p.s. Battery terminals in good condition, ground cleaned?
Thanks,
Eric
TylerDurden
Turbo Charger
Posts: 1285
Joined: Tue Dec 22, 2009 1:01 pm
Location: Michigami, USA

Re: Battery Light not turning on when ING. is engaged

Post by TylerDurden »

Most likely the blue exciter wire has an internal fracture right by its terminal on the alternator. It's a common issue due to the vibration of the diesel. The fracture is often not visible because the blue insulation can remain intact.

To test the system, run the engine and put a clip-lead or other jumper between the blue wire's terminal and the heavy wire going to the battery + terminal. Give the engine a brief rev to about 1500 rpm and see if the alternator kicks on.
Have a nice day.


'91 Jetta ECOdiesel TD - clean & complete (less motor/tranny) for sale

'82 Westy Vanagon 1.9 N/A - 23.5mpg
'86 Jetta TD - 45-50mpg
'81 Dasher Wagon 1.6 N/A - 52mpg
'84 Wasserboxer - DOA, parts donor
'94 Passat wagon VR6
'03 Jetta TDI wagon 230K, 52.3mpg
'89 Jetta N/A - 51mpg
'82 Caddy 1.6 N/A - Sold
wmasscaddy
Cetane Booster
Posts: 83
Joined: Tue Jan 24, 2006 10:00 pm
Location: northampton,ma

Re: Battery Light not turning on when ING. is engaged

Post by wmasscaddy »

Check the 5 amp fuse marked "radio". It powers the whole instrument cluster. A short anywhere in the cluster will cause it to blow. Without that red light the battery won't charge.
82 pickup 1.6 n/a
350,000 + miles lost to broken odo
11mm block, 12mm head
Post Reply